On the horizon: a 'rinse' for washing machines that dries clothes

Think of it as a kind of chemical clothes wringer.
University of Florida engineers have developed a compound that forces clothes in the washer to shed 20 percent more water during the spin cycle than in normal conditions. The result: A load of clothes dries faster in the dryer, saving energy - and reducing homeowners' electricity bills and time spent in the laundry room.

Image: University of Florida chemical engineering doctoral student Daniel Carter demonstrates how a homeowner might pour a clothes-wringing solution into a washer. Carter and Dinesh Shah, a professor of chemical engineering, developed the solution, which forces clothes to shed 20 percent more water during the washer’s spin cycle than under normal conditions. The result: A load of clothes dries faster in the dryer, saving energy and reducing homeowners’ electricity bills. (University of Florida/Kristen Bartlett)

“We feel it’s very cost-effective research and convenient for consumers,” said Dinesh Shah, a professor of chemical engineering and director of the UF Center for Surface Science and Engineering.

Shah and Daniel Carter, a doctoral student in chemical engineering, will publish their second article about their research this month in Langmuir, a surface science journal. UF has applied for a patent on the research, which was funded with $200,000 from Procter & Gamble, a major manufacturer of laundry detergent and related products.

More than 56 percent of Americans own electric dryers, with a typical dryer handling 300 loads per year, Carter said. With the average load requiring from 2.7 to 3 kilowatt hours of electricity, that means drying clothes equates to 5 percent of total residential electricity consumption, costing $2.6 billion annually, Carter said.

A conservative 10 percent reduction in drying times would save consumers $266 million annually. But Shah and Carter say they can do better than that.

Their invention: A water-shedding compound created from a mix of common detergents and fabric softeners.

Carter and Shah said the researchers’ key insight was that the spaces between tiny fibers in the weave of fabrics comprise minute tubes, or capillaries, which retain water due to surface tension. It’s the same phenomenon that causes a submerged straw to hold water when covered at the other end and lifted out of the surface, Carter said.

The researchers reasoned that reducing this surface tension would reduce the water retained by fabric. They first tested this idea using finger-sized copper containers dotted with drain holes. Filled with fabric and water and placed in a centrifuge, the containers mimicked the conditions of spin cycling washing machines – except that the water loss and fabric retention could be easily measured.

When the researchers discovered that some compounds apparently increased water loss, they expanded their experiments to bigger fabrics and a real washer and dryer. The dryer sits in a crowded lab on a scale, allowing Carter to compare different wet loads by weight to their total drying times.

Their experiments revealed that one ratio of a common detergent and fabric softener – five parts detergent, one part fabric softener – added before the spin cycle forced the clothes to shed 20 percent more water than untreated clothes. The clothes then dried 20 percent faster.

Source: University of Florida

Related stories:

Verizon's G'zOne Boulder cell phone is military tough
For all the convenience and security they offer, it doesn't take much to fry a cell phone. Ever bend over to refill Fido's bowl and have your phone tumble out of your pocket and into the water? Or leave it by the edge of a pool only to have some kid come by and cannonball it into oblivion? Even accidentally dropping it onto the pavement or getting sand inside can do serious damage.
Jules Verne prepares for ISS departure
(PhysOrg.com) -- In just a few days time, the historical Jules Verne mission will draw to an end. After the ATV Control Centre commands the opening of the Automated Transfer Vehicle hooks, ESA's first resupply and reboost vehicle will perform a fully automated undocking with the International Space Station on 5 September at 23:30 CEST (21:30 UT).

Nearly Waterless Washing Machine to Debut in 2009
A new washing machine that uses just a cup of water, a pinch of detergent, and about 1,000 small plastic chips to clean clothes may be available for consumers in the UK next year.
Growing use of nanomaterials spurs research to investigate possible downsides
Potential risks from the use of nanomaterials will be explored by three Arizona State University engineering faculty in a project supported by a $400,000 grant from the U.S.Department of Energy Office of Biological and Environmental Research.
Too much nanotechnology may be killing beneficial bacteria
Too much of a good thing could be harmful to the environment. For years, scientists have known about silver’s ability to kill harmful bacteria and, recently, have used this knowledge to create consumer products containing silver nanoparticles. Now, a University of Missouri researcher has found that silver nanoparticles also may destroy benign bacteria that are used to remove ammonia from wastewater treatment systems.
Jules Verne boosts ISS orbit
ESA's Jules Verne ATV was used for the first time early this morning to raise the orbit of the International Space Station. A 740-second burn of the Automated Transfer Vehicle's main engines successfully lifted the altitude of the 280-tonne Station by around 4.5 km to a height of 342 km above the Earth's surface.
ATV Jules Verne automated ship docks to the ISS
ATV Jules Verne, the European Space Agency’s first resupply and reboost vehicle, has successfully performed a fully automated docking with the International Space Station (ISS). This docking marks the beginning of Jules Verne’s main servicing mission to deliver cargo, propellant, water, oxygen and propulsion capacity to the Station, as well as ESA’s entry into the restricted club of the partners able to access the orbital facility by their own means.
Goddard Scientists to Hunt for Treasure and Explore Electric Dust Fountains on the Moon
With Americans set to return to the moon, this time for much longer expeditions, the pressure is on to make the journeys safer and more affordable. That is the mission of NASA's robotic scout, the Lunar Reconnaissance Orbiter, also known as LRO. Scheduled for launch in late 2008, LRO represents NASA's first step toward returning humans to the moon by 2020.

News discussion:

General Science news