Coal-based jet fuel poised for next step

A jet fuel comparable to Jet A or military JP 8, but derived from at least 50 percent bituminous coal, has successfully powered a helicopter jet engine, according to a Penn State fuel scientist. "Because the fuel is 50 percent derived from coal, it could reduce our use of imported petroleum for this purpose by half," says Dr. Harold H. Schobert, professor of fuel science and director of Penn State's Energy Institute. "We have shown in tests that the mix can go to at least 75 percent coal."

The fuel, provisionally designated JP900, is produced in one of two processes under investigation by Schobert. The process uses light cycle oil – a petroleum byproduct -- and coal-derived refined chemical oil -- a byproduct of the coke industry. The researchers mix the two components and add hydrogen. When distilled, jet fuel comes off as a distillate. The process can be carried out in existing refineries with some retrofitting and small amounts of the leftover components will feed into various portions of the petroleum stream. The lighter portions will go to the pool of chemicals that make gasoline and the heavier ones go to the diesel or fuel oil streams.

"The combustion tests showed that JP900 meets or exceeds almost all specification for JP8 and Jet A," Schobert told attendees at the 231st meeting of the American Chemical Society today (March 27) in Atlanta, Ga.

These tests showed that JP900 has a flash point higher than required for JP8, a lower viscosity and freezing point and a higher smoke point. The coal-based fuel is lower in aromatics – such compounds as benzene and toluene – than conventional jet fuels and is almost sulfur free. From an energy point of view, JP900 produces almost exactly the same Btu as JP8.

Not only does JP900 meet most of the specification for JP8, but it also has the high flash point required of JP5, naval jet fuel and the thermal stability of JP7, a high performance fuel.

While originally, this project began to develop jet fuel for the next generation of high performance aircraft that would require very thermally stable fuels. Now that fuel prices have soared and we need to lower fuel costs, develop secure fuel sources and decrease dependence on foreign oil, there is a major shift in thinking about fuel and its sources.

"The fact that our fuel is almost dead on to JP 8 is something that the Air Force likes," says Schobert. "This fuel was intended to be a high heat sink fuel, which it is, but it can also be used in existing engines."

The project now targets coal-based replacement for existing fuels with the hope that this will interest both commercial and military users. So far the Penn State project has produced 500 gallons of fuel in a pilot plant operated by Intertek of Warren, Pa. The Penn State researcher would now like to produce about 4,500 gallons, or about 100 barrels, of the fuel for future testing by the Air Force and others.

Source: Penn State

Related stories:

Coal-based fuels and products hit the refinery
A variety of end products including jet fuel, gasoline, carbon anodes and heating oil may be possible using existing refineries and combinations of coal and refinery by-products, according to a team of Penn State researchers.
Probing Question: Does commercial jet traffic affect climate?
It's hard to dispute that car and truck emissions affect the environment. Tail pipes cough out a brew of gases that contribute to smog, ground-level ozone and global warming. But what about jet pollution?
Gamma-ray burst mystery is solved
An international team of scientists using three NASA satellites and a host of ground-based telescopes believes it has solved the greatest remaining mystery of the mysterious gamma-ray bursts (GRBs), the most powerful explosions in the universe. The shorter of two versions of these bursts appear to be caused by the collision of closely orbiting neutron stars or one of those compact stars and a black hole, said Don Lamb, the Louis Block Professor in Astronomy & Astrophysics at the University of Chicago.
Whether brown or red, algae can produce plenty of green fuel
Having studied the physiology of algae for more than 30 years, Rose Ann Cattolico is convinced the plant life found in oceans and ponds can be a major source of environmentally friendly fuels for everything from cars and lawn mowers to jet airplanes.
Airlines push for homegrown jet fuel
(AP) -- With the price of oil still above $100 a barrel, everything from wood chips to chicken fat is being scrutinized as an alternative to traditional fuel. But when it comes to airplanes, finding the right mix poses a special challenge.
Probing Question: Is peak oil a myth?
Unprecedented summer gasoline prices are squeezing Americans' wallets and also expanding their vocabularies, as terms like "peak oil" gain common usage.
Algae jet fuel makes splash at international air show
Researchers Qiang Hu and Milton Sommerfeld from ASU’s Department of Applied Biosciences recently flew to London to share their findings and research on the application of algae-based oils for creating biofuels at the Farnborough International Air Show.
Phoenix Mars Team Opens Window on Scientific Process
(PhysOrg.com) -- Phoenix Mars mission scientists spoke today on research in progress concerning an ongoing investigation of perchlorate salts detected in soil analyzed by the wet chemistry laboratory aboard NASA's Phoenix Lander.

News discussion:

Space & Earth science news