What if that happens again next year?
What if farmers decide against crop rotations and plant corn on the same fields, year after year? Or, what if farmers begin growing biomass crops such as switchgrass for the production of ethanol from plant fiber?
Will soil lose fertility? Will erosion increase? Will the amount of energy needed to produce biofuels go up or down? Will farm income increase or decrease?
Will the bioeconomy be sustainable?
Robert Anex, an Iowa State associate professor of agricultural and biosystems engineering and associate director of Iowa State's Office of Biorenewables Programs, is working to answer those and other questions about the transition to an agriculture that produces biomass as well as food and fiber.
One answer is that American agriculture is likely to change.
"It may well be that the development of biomass-based crops production systems can have as profound an impact on agriculture and its environmental footprint as it does on energy security and the global climate," Anex and co-authors Andrew Heggenstaller and Matt Liebman of Iowa State's agronomy department and Lee Lynd and Mark Laser of Dartmouth College wrote in a recent paper. "Whether this is a positive impact or a negative impact will depend largely on how biomass feedstocks are produced and converted, and the extent to which these two activities are integrated."
Their paper, "Potential for Enhanced Nutrient Cycling through Coupling of Agricultural and Bioenergy Systems," was recently published online by Crop Science, the official publication of the Crop Science Society of America.
The paper reports that as much as 78 percent of the nitrogen fertilizer needed for crops could be recovered from an integrated biological and thermochemical process that converts switchgrass to ethanol. The study says such nutrient recovery and recycling could significantly improve the sustainability of biomass production and the amount of energy required to produce ethanol from plant fiber.
The researchers say the nutrient recovery could happen this way: Plant fiber would be converted to liquid fuels by pre-treatments and fermentation. The co-products of fermentation would be dried and heated to turn the solids into gases. The gasification would leave plant nutrients in the resulting ash and ammonia. The nutrients in both streams could be recovered and returned to the fields that produced the biomass.
And that potential for nutrient recycling means there's potential for a new kind of agriculture feeding a sustainable bioeconomy.
"By creating a large, new domestic demand for agricultural products, the advent of commercial-scale conversion of biomass into ethanol and other industrial chemicals is likely to have a strong influence on the design of agricultural systems," the researchers wrote. "The possibility of recycling nutrients from the biorefinery to the agricultural system that produces the feedstock may allow substantial improvements in both sustainability and production efficiency."
But, sustaining biomass production is a complex system that depends on many variables such as soil type and slope, soil organic matter and the amount of biomass actually harvested.
To help farmers begin to understand how collecting biomass from their fields may affect soil fertility, erosion, energy needs, labor and the bottom line, Anex and a team of Iowa State researchers have added bioeconomy elements to I-FARM, a Web tool that helps farmers simulate and plan various changes to their operations.
I-FARM is free and can be found at
http://i-farmtools.org . Its focus is on the upper Midwest but weather and soils data from 28 states are accessible from its database.
In one simulation, the I-FARM research team (Anex, Ed van Ouwerkerk, an Iowa State research associate in agricultural and biosystems engineering; Tom Richard, an associate professor of agricultural and biological engineering at Penn State University; Amritpal Kang, an Iowa State graduate student; and Brian Gelder, an Iowa State postdoctoral research associate) studied the effects of harvesting corn stalks and leaves on three farms in northwest Iowa's Palo Alto County. One grain farm harvested no stover, one harvested 1,809 dry tons of stover a year and the other harvested 3,077 dry tons a year.
The simulations found the farm that harvested the most stover also needed the most fertilizer, had the most erosion and barely returned sustainable levels of organic matter to the soil. That farm also recorded the highest net farm income before taxes.
Anex's study of the sustainability of the bioeconomy is being supported, in part, by grants from the U.S. Department of Agriculture, the U.S. Department of Energy and the National Science Foundation.
The studies are helping researchers answer some questions about the sustainability of agriculture in a bioeconomy, Anex said. But there are still lots of questions about how everything in a new agricultural system would fit together.
"Despite the promise of alternative crops and cropping systems as well as the nutrient recovery and recycling concepts examined here, there are still many questions that remain about their practical implementation," Anex and the other researchers wrote in their paper. "The issues that have been addressed here and the questions that have been raised are only a small subset of those that must be addressed if we are to usher in a new and beneficial agricultural revolution."
Source: Iowa State University
Related stories:
From Sugar to Gasoline
Following independent paths of investigation, two research teams are announcing this month that they have successfully converted sugar-potentially derived from agricultural waste and non-food plants-into gasoline, diesel, jet fuel and a range of other valuable chemicals.
Self seeding: An innovative management system
Winter cover crops provide important ecological functions that include nutrient cycling and soil cover. Although cover crop benefits to agroecosystems are well documented, cover crop use in agronomic farming systems remains low. Winter cover crops are usually planted in the fall after cash crop harvest and killed the following spring before planting the next cash crop. Recent research has identified time and money as major impediments to farmer adoption of winter cover crops. Developing innovative cover crop management systems could increase the use of winter cover crops.
Researchers improving plastics made from corn and soy proteins
David Grewell picked up the little plastic model of a molecule he keeps in his office. He scrunched the model's folding pieces into a ball. That's about the shape of a soy or corn protein, said Grewell, an Iowa State University assistant professor of agricultural and biosystems engineering. Then he unfolded the model into a long, straight loop. That's what happens when researchers add some glycerin – a byproduct of biodiesel production – and some water to the molecule. And that's how biorenewable, biodegradable plastics can be made from the proteins in Iowa crops.
Researchers convert farm waste to bio-oil
Samy Sadaka reached into a garbage bag, picked up a mixture of cow manure and corn stalks, let it run through his fingers and invited a visitor to do the same... It wasn't that bad.
Researchers developing wireless soil sensors to improve farming
Ratnesh Kumar keeps his prototype soil sensors buried in a box under his desk. He hopes that one day farmers will be burying the devices under their crops.
Newresearch shows mad cow disease also caused by genetic mutation
New findings about the causes of mad cow disease show that sometimes it may be genetic. "We now know it's also in the genes of cattle," said Juergen A. Richt, Regents Distinguished Professor of Diagnostic Medicine and Pathobiology at Kansas State University's College of Veterinary Medicine.
Study finds link between a mother's stress and her child becoming overweight
A mother's stress may contribute to her young children being overweight in low income households with sufficient food, according to a new Iowa State University study published in the September issue of
Pediatrics, the professional journal of the American Academy of Pediatrics. The study analyzed data collected from 841 children in 425 households in the 1999-2002 National Health and Nutrition Examination Survey.
Researchers map first plant-parasitic nematode genome sequence
(PhysOrg.com) -- There are numerous plant-parasitic nematodes in the world, but only a handful are responsible for the largest part of an estimated $157 billion in agricultural damage globally every year. Nematodes are small worms that burrow into plant roots and feed off living cells.
