Handheld windmills serve as electric generators

It’s not quite nanotechnology, but these inches-long windmills can generate small amounts of electric energy to power a variety of low-voltage applications. Since they’re made entirely of plastic, they cost just dollars to manufacture, offering potential for many uses including battery recharging, lighting in remote areas, and wireless sensors.

As a clean, free, and natural option, harnessing wind power for use as a source of energy is appealing, although it’s usually considered on a large scale. Windmill farms with 100s of giant windmills have been built to supply partial power to towns, but wind power can also have simple applications on a small scale. For example, some bicycle lights work by wind power, but the electromagnetic converter they use requires large amounts of mechanical energy, which is not available for most applications.

However, scientists Robert Myers, Mike Vickers, Hyeoungwoo Kim, and Shashank Priya from the University of Texas Arlington have recently investigated other possible designs that might make a small-scale windmill feasible. To convert wind energy into electric energy, they use a piezoelectric structure, where bimorphs (thin plastic sheets) aligned in a row are caused to vibrate via a lever and crankshaft which is attached to the wind vanes.

“Piezoelectrics require a very small magnitude of deflection to generate high voltages,” Priya explained to PhysOrg.com. “We have recently reported improvements in the piezoelectric ceramic material to enhance the energy harvesting efficiency. As the material and transducer structure continues to improve, piezoelectrics will become more promising. Piezoelectrics are a high voltage-low current source, while electromagnetics are a low voltage-high current source. So in our next generation system, we are designing a combinatory system which will provide better power density.”

The scientists’ most promising design so far involves three 5-in. (13-cm.) fans mounted on a single shaft through an adjustable gear ratio. Attached to the shaft, a crank arm pulls a lever that is attached to two rows of nine bimorphs. The lever causes the bimorphs to vibrate, converting random wind flow into synchronous mechanical motion. The entire generator size, which is 3.5x4x5.5 in.³, is made of acrylonitrile butadiene styrene (ABS) plastic.

At an average wind speed of 10 mph, the windmill can generate 5 mW of continuous power at a rate of 12 volts. Although a fairly small amount of energy, the windmill can still power sensors, switches, alarms, and wirelessly transmit data, which would be especially useful in remote locations. Further, the generated power can be stored in a supercapacitor for delayed use, and minimally works at wind speeds as low as 5.4 mph.

“Our results have shown that at a wind speed of 10 mph, the accumulated energy in a 0.1F capacitor shows output power levels around 130 mW with current around 35 mA across the 100W resistive load,” Priya said. “The saturation voltage for the capacitor was around 5.5~6V. After 30 minutes, the capacitor was almost charged and saturated.”

The group plans to use their current models as guidelines for designing more efficient prototypes, including the piezoelectric-electromagnetic hybrid. The scientists predict that small-scale windmills can supply energy for powering weather stations, lighting inside tunnels, and monitoring national borders.

“We have recently implemented a wind-powered wireless sensor network using this system,” said Priya. “We are currently working on a design which will enhance the power density by one order of magnitude. The challenge is in capturing the mechanical energy from wind effectively.”

Citation: Myers, Robert, Vickers, Mike, Kim, Hyeoungwoo, and Priya, Shashank. “Small scale windmill.” Applied Physics Letters 90, 054106 (2007).

By Lisa Zyga, Copyright 2007 PhysOrg.com.
All rights reserved. This material may not be published, broadcast, rewritten or redistributed in whole or part without the express written permission of PhysOrg.com.

Related stories:

AP Investigation: Ike environmental toll apparent
(AP) -- Hurricane Ike's winds and massive waves destroyed oil platforms, tossed storage tanks and punctured pipelines. The environmental damage only now is becoming apparent: At least a half million gallons of crude oil spilled into the Gulf of Mexico and the marshes, bayous and bays of Louisiana and Texas, according to an analysis of federal data by The Associated Press.
This is your grid on brains
(PhysOrg.com) -- Managing power networks in the future may involve a little more brain power than it does today, if researchers at Missouri University of Science and Technology succeed in a new project that involves literally tapping brain cells grown on networks of electrodes.
Scientists explore putting electric cars on a two-way power street
Think of it as the end of cars' slacker days: No more sitting idle for hours in parking lots or garages racking up payments, but instead earning their keep by providing power to the electricity grid.
CSIRO's UltraBattery goes global in the auto sector
The CSIRO-invented UltraBattery is set to have a global impact on greenhouse gas emissions after Japan's Furukawa Battery Company, which has already begun production of the UltraBattery, and US manufacturer, East Penn, today signed an international commercialisation and distribution agreement for the technology.
Carbon dioxide 'scrubber' captures greenhouse gases
University of Calgary climate change scientist David Keith and his team are working to efficiently capture the greenhouse gas carbon dioxide directly from the air, using near-commercial technology.
New graphene-based material clarifies graphite oxide chemistry
A new "graphene-based" material that helps solve the structure of graphite oxide and could lead to other potential discoveries of the one-atom thick substance called graphene, which has applications in nanoelectronics, energy storage and production, and transportation such as airplanes and cars has been created by researchers at The University of Texas at Austin.
Ocean offers hope for green energy
Five miles off the southern tip of Long Beach Island, an oversize yellow buoy floats alone, purposefully mounting the waves and occasionally phoning home.
Google and GE allies in quest for clean energy (Update)
Internet titan Google and technology colossus General Electric said Wednesday they are joining forces to promote a "smart" US electric power grid and clean energy.

News discussion:

Handheld windmills serve as electric generators in Technology news